Replacing the Rear Main Seal 2000 S40

Replacing the rear main seal on S40. Very good write-up with plenty of pictures to help. Replacing the Rear Main Seal 2000 S40 Related posts:Options to Fix a Rear Main Seal Leak Rear Camshaft Seal Replacement Rear main seal change/clutch … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Options to Fix a Rear Main Seal Leak
2. Rear Camshaft Seal Replacement
3. Rear main seal change/clutch removal 850 Manual

S80 — Can Performance be Improved?

Performance Upgrade Path for a 1999 S80 T6 Short answer: there isn’t one. Long answer: there is, if you’re willing to spend lots of money to get there, and find a way around an inherently weak transmission. To be blunt, … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. S60 Weak Engine Performance
2. S80 Transmission Stuck in Performance Mode
3. Increase Performance: Chips

Volvo S60: Sorting out ETM vs Transmission Problems

Installing a new rebuilt transmission without doing the following is fruitless: Full transmission fluid flush Go to a dealer or Volvo indie shop to get rid of the stop neutral transmission “feature” Clear and reset all the adaptions And do … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Transtar1 Volvo Transmission Parts
2. Volvo XC90 Transmission Problems
3. V70 – Replacing B4 Servo Cover Fixes Shift Flaring

Rear main seal change/clutch removal 850 Manual

This is a DIY tutorial covering removing the transmission and replacing the clutch on a Volvo 850 manual transmission. For starters, I put the front of the car on stands, doesnt have to be really high. Just make sure you … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Options to Fix a Rear Main Seal Leak
2. Rear Main Seal Leak Volvo 760
3. 1998 Volvo V70 Instrument Cluster Removal/Bulb Change

Transtar1 Volvo Transmission Parts

Valve body and related transmission rebuild parts… an MVS user said he found valvebodyxpress.com through Transtar1 and got what he needed so, hey, just passing this along. If you want to read the Volvo forum topic, here she is… 55-50 … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. New Forum — Volvo Parts
2. Timing Belt Change with Related Parts
3. S80 Transmission Stuck in Performance Mode

Buy a New Transmission or Rebuild: 2001 V70

What to expect when you have a 2001 Volvo transmission (known for failures… early and often) replaced by a dealer. Is it worth it to replace or have the transmission rebuilt? Would a new transmission going back into that year and model … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Another 2001 Auto Transmission Sad Story
2. How to Make the Transmission Last in 2001 XC70
3. S80 Transmission Stuck in Performance Mode

Volvo 240 Diagnose & Repair: TPS, MAF, PCV, Acceleration, Fluids

This Volvo Forum topic covers a whole slew of 240 issues. It’s “all over the map”, but you’ll find something to interest most 240 owners in it. mass airflow sensor (MAF): how to check it throttle position sensor (TPS): how … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Change 740/760 Transmission Fluid? How Much?
2. S80 1G 6Cyl Auto Transmission Fluid & Filter Change How-To
3. XC90 Transmission Fluid Flush

Another 2001 Auto Transmission Sad Story

Another Volvo Forum topic regarding the death of a 2001 Volvo automatic transmission, this one with some insight by those with either mechanical and Volvo sales backgrounds. Just to let everyone know, I (ME) was the beta tester for the … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. ALL 2001 trannies eventually go bad, they’re junk?
2. How to Make the Transmission Last in 2001 XC70
3. Should I trust the dealership? My transmission dilemma.

Mobil 1 Synthetic ATF is not 3309 Compliant

Mobil 1 Synthetic ATF lost 3309 compliance and the spec was removed from the containers. Mobil 1 Synthetic ATF is not 3309 Compliant Related posts:XC90 Transmission Fluid Flush Percent of Synthetic in Semi-Synthetic Oil? Transmission Fluid 2000+ Requirement

-- Volvo Forum and Help for Volvo Owners since 2001

1. XC90 Transmission Fluid Flush
2. Percent of Synthetic in Semi-Synthetic Oil?
3. Transmission Fluid 2000+ Requirement

AWD Volvo Whining Noise

Diagnosis Help and Advice on XC90 AWD System It had a noise when accelerating when cold, it sounded like someone tapping a pan under the car. My friend found the problem to be the rear output CV shaft was lacking … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Volvo V70 Straight Pipe Exhaust Mod
2. Volvo XC90 Rear Differential
3. Pre-2001 Volvo XC70 AWD Drive Shaft Removal

Sticky Automatic Shifter? Here’s Your Cheap Fix.

I had the sticky shifter problem , broken button, and I just could not see spending $38 on a replacement button. Off to the local pick and pull. Seems like all, or most, of the buttons on the 70 series … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Towing 740 w/automatic Trans
2. Automatic Climate Control Problems? Try This!!
3. Volvo 850 Climate Control Knob Repair

How to Maintain Your AWD Volvo’s Driveshaft

For all AWD Volvo Models MVS Forum member Jimmy tells us explicitly how to make your AWD Volvo system go well over 100k miles. If you’re reading this with 150k+ miles on yours, and you haven’t “done anything” to extend … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Pre-2001 Volvo XC70 AWD Drive Shaft Removal
2. Front Driveshaft Removal V70 XC
3. Front Driveshaft Remove + Replace

V70 – Replacing B4 Servo Cover Fixes Shift Flaring

MVS Forum member T5AUS did a transmission fluid flush (commonly called a Drain and Fill) on his 2001 V70 T5, and topped up with 3309 fluid, which virtually cured all the erratic shift flaring. But he was still getting odd flares … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. V70 Cargo Cover/Tonneau Cover Repair
2. Replacing the #2 Shift Solenoid
3. Tutorial – Replacing the Starter Motor 1998 S70

How Often Should You Flush Your Transmission Fluid?

I have been flushing my ATF (as opposed to a Transmission Drain & Fill… in other words: where I disconnect the cooler hose and flush ATF) using the following guidelines: Mobil Synthetic ATF (It take about 9-10 qts for a … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. XC90 Transmission Fluid Flush
2. New Modified Transmission Flush Method with Pictures
3. Transmission Fluid Flush Tip 2

About to buy used 2000 V70 w/148K miles–what to ask

What to Look For When Buying a Volvo V70 or XC70 Another informative group of tips and items to check when buying a late 1990s or 2000 model year Volvo V70 or XC70. What to look for with the AWD … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Persistant Exhaust Manifold leaks
2. 2000 V40 Temp Gauge Erratic and Engine Surging
3. 2000 S80 ABS Module remanufacturers

How to change rear bevel fluid on AWD P2 Volvos

Tutorial – Change Bevel/Angle Fluid on AWD 2003+ Volvos Before proceeding with this tutorial, ensure that your Volvo AWD system is the same one as is on my 2004 V70 R. If it is, you’ll have no problem. If not, … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. How to change Haldex fluid on AWD P2 Volvos
2. Bevel Gear Maintenance on 1997-2002 Volvo AWD Cars
3. Change S80 Trans Fluid Or Not?

How to change Haldex fluid on AWD P2 Volvos

Volvo Haldex Fluid Change Tutorial This is something most people can do… the hardest part is getting the old fluid out (no drain plug). Angle gear fluid change tutorial coming soon. How to change angle gear and Haldex fluid on … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Bevel Gear Maintenance on 1997-2002 Volvo AWD Cars
2. S80 Oil and Filter Change How-To (& other “P2″ Volvos)
3. S80 1G 6Cyl Auto Transmission Fluid & Filter Change How-To

Should I trust the dealership? My transmission dilemma.

How to Deal With Volvo Dealers re: Failing Transmissions Volvo forum member scottymac bought a used XC70 and found that a) the transmission was showing signs of neglect and early failure, and b) the Volvo dealer he went to lied … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. Avoid XC90 T6 – Transmission Issues
2. Volvo XC90 Transmission Problems
3. Replacing an 850 Transmission

Just Got Back from Volvo Specialists (Denver)

…and wow do they know their stuff. Volvo Specialists are a very talented crew with a substantial amount of experience gained by working for local dealer service departments (McDonald Volvo, Rickenbaugh Volvo). I met owner Mike, manager Brett, and about … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. XC90 Transmission Fluid Flush
2. Change 740/760 Transmission Fluid? How Much?
3. Volvo High Milage Club Badge History

PNP Removal, Cleaning, Installation, Alignment

This is a write up for the removal, cleaning, installation and alignment of the PNP switch on a 1996 854, I’m pretty sure other year 850′s as well as s/v70′s are very similar if not identical. Part 1: PNP Removal … Continue reading →

-- Volvo Forum and Help for Volvo Owners since 2001

1. ETM Removal and Cleaning
2. PNP Alignment without the tool
3. Instructions for accessory part installation