IPD sale Volvo Parts

Search found 6215 matches

by jimmy57
Sat Jun 15, 2019 10:02 pm
Forum: Volvo C30 Forum, C70 Forum 2006+, S40 & V50 Forum 2004 ½ +
Topic: V50 2006 - sensor attach to bottom rear of battery box
Replies: 2
Views: 42

Re: V50 2006 - sensor attach to bottom rear of battery box

The alternator has remote charging voltage control. The battery temp is a main determining factor in what the voltage will be. Cooler battery needs and will tolerate higher voltage without evaporating water from the electrolyte.
by jimmy57
Fri Jun 14, 2019 3:35 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: Time to say goodbye....T5
Replies: 10
Views: 175

Re: Time to say goodbye....T5

"Today Precopster's V70 T5 went to its final resting place. The vehicle had a DNR order filed (Do Not Repair) and some recent failures sealed it demise. The tow truck procession traveled a route lined with P2 wagon owners standing at attention with tools hoping for a chance to grab needed bits form ...
by jimmy57
Fri Jun 14, 2019 3:28 pm
Forum: Volvo S40 & V40 Forum 2000-2004
Topic: High fuel trims. Bad ECU or what?
Replies: 4
Views: 94

Re: High fuel trims. Bad ECU or what?

On an engine with wear the fuel trim is not going to be near 0. I work on high mile cars all the time with fuel trim values of 10% and the crankcase vent and other stuff is working properly. The emissions warning will alert if it gets near 25%.
by jimmy57
Thu Jun 13, 2019 7:24 am
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: Tie Rod Jam Nut vs Air Gun Question
Replies: 2
Views: 68

Re: Tie Rod Jam Nut vs Air Gun Question

I have had success using two hammers to get those free. One big hammer on a flat of nut behind and the other big hammer strikes the near flat. Then repeat on another pair of opposing flats.
by jimmy57
Wed Jun 12, 2019 11:51 am
Forum: Volvo 240, 740, 760, 780, Bertone, 940, 960, V90, S90 Forum
Topic: AC Compressor Help (I'm stuck) - '97 960
Replies: 11
Views: 128

Re: AC Compressor Help (I'm stuck) - '97 960

The item on condenser is the high pressure sensor, 5v, ground, and signal to ECM of .4 to 4.2V, increases with higher pressure. It would not blow a fuse, the ECM will shut down the 5V supply if shorted. The pressostat is on the accumulator by firewall on passenger side but it interrupts a compressor...
by jimmy57
Thu Jun 06, 2019 7:11 am
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: 2004 V70 driver side axle question: the Big Round Rubber Cushion
Replies: 5
Views: 152

Re: 2004 V70 driver side axle question: the Big Round Rubber Cushion

I have never been able to detect any difference when a CV axle is replaced and that damper is not on new part.
by jimmy57
Wed Jun 05, 2019 5:34 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: Rusted Flange Screws 2007 V70 2.5t
Replies: 10
Views: 234

Re: Rusted Flange Screws 2007 V70 2.5t

You can get them at a good hardware. Take out one of each location and measure from under head to end of threads, in mm.
A wrecker that allows you to harvest those parts off severely crashed unuseable parts of cars is also a good source.
by jimmy57
Wed Jun 05, 2019 5:31 pm
Forum: Volvo 850, S70, V70, C70, XC models 1992-2000
Topic: Question on timing post 98 cars
Replies: 3
Views: 66

Re: Question on timing post 98 cars

The ignition timing will not need any compensation. The sensor reads the perforated surface of flywheel. The divider between the holes are 6 degree spaced with a missing divider to note 90 deg BTDC #1. The flywheel fits only in one postion and with a dowel. The flywheel manufacturing and crankshaft ...
by jimmy57
Sun Jun 02, 2019 8:02 am
Forum: Volvo XC90 Forum
Topic: Volvo XC 90, 2008, 3.2, Problem with A/C turning on
Replies: 2
Views: 88

Re: Volvo XC 90, 2008, 3.2, Problem with A/C turning on

new compressor or used compressor? The most common reason for your symptoms on that engine is the solenoid stuck into compressor is worn and binding. Once the compressor gets hot the expansion releases the bind of the solenoid and it works until car is parked and cools down. The solenoid is availabl...
by jimmy57
Sat Jun 01, 2019 9:04 am
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: 2004 V70, S60 GKN OUTER CV boot is now Plastic!
Replies: 35
Views: 425

Re: 2004 V70, S60 GKN OUTER CV boot is now Plastic!

The inner joint only goes through up and down a few degrees. The outer must tolerate up/down and left/right and do it at the same time so the more robust piece was needed there. The reason that inners are so often trunnions and the outer are always knuckle and ball. There are many models (not Volvo)...