IPD sale XeMODeX - Experts in Volvo Electronics

Search found 951 matches

by chrism
Tue Aug 13, 2019 1:40 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: 2006 V70 R -- heater core hoses
Replies: 8
Views: 98

Re: 2006 V70 R -- heater core hoses

What is it that leaks oil so badly that you have to protect the hoses from it? Will the new engine put an end to the leaking?
by chrism
Thu Aug 08, 2019 5:26 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: Approx cost of windshield replacement
Replies: 12
Views: 163

Re: Approx cost of windshield replacement

I had mine replaced about four years ago after I cracked it with my elbow when removing the shift lever. It took the guy all of about 25 minutes start to finish. At the time it was about $140 for a Pilkington without rain sensor. If you have a rain sensor you’ll pay a bit more.
by chrism
Wed Aug 07, 2019 6:21 am
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: 2001 V70 Xc Car locks itself. Wiring or Module? Topic is solved
Replies: 23
Views: 335

Re: Car locks itself. Wiring or Module? Topic is solved

If your old DDM has a little white sticker with two or three numbers on it then you want to match those numbers to the sticker on the replacement DDM. I replaced mine a couple years ago with a junkyard part and as I recall I was able to match two of the three numbers. I also made sure the replacemen...
by chrism
Fri Aug 02, 2019 12:21 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: HVAC Woes
Replies: 11
Views: 174

Re: HVAC Woes

Thanks for the reply - but would this cause low/restricted air-flow as well? As I recall those linkages drive a couple different flapper doors on each side of the unit. I believe it could be affecting the overall flow especially if the problem is only on one side of the car. Is the airflow ALWAYS s...
by chrism
Thu Aug 01, 2019 11:07 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: HVAC Woes
Replies: 11
Views: 174

Re: HVAC Woes

There are plastic blend door actuators on both the LH and RH sides of the HVAC unit. The actuators on the drivers side tend to interfere with the removal and replacement of the heater core especially if they weren't “parked” in the correct position before beginning the disassembly. This can result i...
by chrism
Sun Jul 28, 2019 9:55 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: Help with transmission fill bolt
Replies: 12
Views: 218

Re: Help with transmission fill bolt

It’s a plane looking six point bolt on my 2003. I guess Volvo thought switching to five point would discourage some accidental removals.
by chrism
Sun Jul 28, 2019 4:18 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: 2005 S60 CEL P0016 & P0017
Replies: 2
Views: 53

Re: 2005 S60 CEL P0016 & P0017

From what I read about those codes, they apparently refer to the timing correlation BETWEEN the crank and cam(s) and not some much that the sensors are bad. How’s the condition and tension of the timing belt? Could it have slipped a tooth? Maybe a VVT servo issue? Just tossing out some ideas to get ...
by chrism
Thu Jul 25, 2019 6:30 am
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: Drain/relieve fuel prior fuel filter change? Topic is solved
Replies: 7
Views: 119

Re: Drain/relieve fuel prior fuel filter change? Topic is solved

I always thought the Volvo recommended procedure was a bit over-kill. If you want to release any residual pressure it’s easily done by spraying the fuel rail Schaefer valve into a rag.
by chrism
Mon Jul 15, 2019 6:32 pm
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: PCV R&R - Losing the battle to the dreaded hidden Intake bolt Topic is solved
Replies: 74
Views: 1132

Re: PCV R&R - Losing the battle to the dreaded hidden Intake bolt Topic is solved

I cut it down to 12.4mm and still can't get it to fit. Can you grind the socket down to a smaller O.D. up by the end that receives the extension? The closer to the top, the smaller the diameter. Someone in this thread mentioned that those bolts don’t require much torque so you may be able to remove...
by chrism
Fri Jul 12, 2019 10:46 am
Forum: Volvo V70 & XC-70 2001-2007, S60 2001-2009
Topic: PCV R&R - Losing the battle to the dreaded hidden Intake bolt Topic is solved
Replies: 74
Views: 1132

Re: PCV R&R - Losing the battle to the dreaded hidden Intake bolt Topic is solved

Point well taken there. Of course we’re assuming that the person who is reassembling it will be able to torque that little bugger exactly right anyway? Mmmm, maybe.....