Wet floor again.

Help, Advice, Owners' Discussion and DIY Tutorials on Volvo's stylish, distinctive P2 platform cars sold as model years 2001-2007 (North American market year designations).

2001 - 2007 V70
2001 - 2004 V70 XC (Cross Country)
2004 - 2007 XC70 (Cross Country)
2001 - 2009 S60
2003 - 2007 S60 R
2004 - 2007 V70 R

Post Reply
AlanS
Posts: 535
Joined: Sat Aug 12, 2006 12:34 pm
Year and Model:
Location:

Wet floor again.

Post by AlanS »

I found the source of the leak (2006 xc70) but not the reason. Water is leaking from the cabin filter chamber on the pass. side. If I were to open it up, a nice amt of water would exit. I originally thought it was the cowl drains, as this is what happened to my 850...I kept them clean, rain today in NY...water dripping from the cabin filter housing. Any ideas?

User avatar
oragex
Posts: 5302
Joined: Fri May 24, 2013 6:20 am
Year and Model: S60 2003
Location: Canada
Has thanked: 102 times
Been thanked: 328 times
Contact:

Post by oragex »

There's about a dozen of 'sources' actually. May have a search on Youtube. Here's just one of the vids

The bottom cover of the cabin filter is made of plastic and has a small rubber seal around. The plastic bends with time, I'd suggest replacing this cover if available at the dealer. Myself I've used some silicone but it's harder to remove the next time.

Also, I'd inspect the drain tube from the cabin blower unit - same place but near the right wall. The rubber tube goes into the wall and exists, can be removed and cleaned at the bottom end. I'd also make sure the blower has all it's mounting screws properly secured - I believe 5, one of which is located almost behind the blower.

User avatar
shiloh51933
Posts: 964
Joined: Fri Mar 05, 2010 7:12 pm
Year and Model: 04 XC70/'98 V70XC
Location: New York
Has thanked: 11 times
Been thanked: 11 times

Post by shiloh51933 »

I'd pull cowl out to inspect under it and they sunroof drains have been known to make a puddle on floor. A friend on mine had an '04 XC90 that leaked due to sunroof drains and fouled up a couple of modules /harenes which would cause his XC90 to go into limp mode. He would turn her off then restart her to reset computers but he procrastinated to bring her in for diagnostic and burned out his trans constantly driving in limp home mode.
If U Wanna Play U Gotta Pay!!

Post Reply