1993 Volvo 850 fuel pump location

loyd198 · Post by **loyd198** » 29 Jul 2010, 05:31

Where is the access to the fuel pump for a 1993 Vovlo 850 GLT with 2.4 5 cylinder motor ? I was told by a mechanic it is accessed through the trunk...is this correct ? If so..where exactly is it in the trunk and how do I get to it ? Thanks

Post by **confused_al** » 29 Jul 2010, 07:21

Here it is,
https://www.matthewsvolvosite.com/forums ... 6515#56515
In case you need replace w/ cheaper pump,
http://volvospeed.com/vs_forum/index.ph ... t-how-too/
Where you can get for good price,
http://www.europartsdirect.com/

loyd198 · Post by **loyd198** » 29 Jul 2010, 21:33

OK..that gives me a general idea..but I really need to know where it is in a four door sedan. The how to on the cheaper one was very helpful. OK anybody ..tell me where the exact location is in the trunk on my 1993 850 GLT sedan.

Post by **jblackburn** » 29 Jul 2010, 21:36

Pull up the carpet. You will see a metal hatch over the pump towards the back seat, right side of the car.

loyd198 · Post by **loyd198** » 31 Jul 2010, 16:12

Thanks, found it today when replacing my rear shocks ! Next job, replacing it when I get the new one this week.

loyd198 · Post by **loyd198** » 31 Jul 2010, 16:14

Just curious, what is the other part in the trunk that has the cover on it. It looks like it also goes in the fuel tank ?

Post by **misha** » 31 Jul 2010, 17:45

That is fuel level sender unit.

loyd198 · Post by **loyd198** » 01 Aug 2010, 11:56

Thanks for all the help from everyone ! 203,000 miles and still going strong..now to get ready for the next 200,000 !

barteldp · Post by **barteldp** » 05 Feb 2013, 09:58

I'm really struggling with this.

I have replaced the fuel filter and the fuel pump in this 1993 Volvo 850 however I still do not seem to be getting fuel to the engine. When I put my finger on the bicycle valve looking thing on the engine very little comes out.

I've hot wired the relay to verify that it isn't the issue it is not. The car cranks over great just no fuel.

I put my meter on the fuel pump looks like 8 volts and some change are going to the pump, but I really don't feel the pump turning on.

What else should I look at?

Post by **Ozark Lee** » 05 Feb 2013, 12:23

I put my meter on the fuel pump looks like 8 volts and some change are going to the pump, but I really don't feel the pump turning on.

You should be getting full battery voltage - in the upper 12 to lower 13 volt range. Sounds like a wiring or a ground problem.

...Lee