Login Register

What has failed on your 1992-2000 FWD or AWD Volvo?

Post Reply

What has failed on your 1992-2000 FWD or AWD Volvo?

02 sensor
150
2%
a/c clutch, compressor, accumulator tank
89
1%
a/c evaporator, purge valve, pressure switch
54
1%
a/c receiver-drier
21
0%
ABS module
246
4%
airguide, skidplate
63
1%
alarm status indicator
13
0%
alternator
80
1%
ball joints
142
2%
battery cable
43
1%
bevel gear
19
0%
brake booster check valve
5
0%
brake caliper
84
1%
brake hoses
54
1%
cabin temperature sensor
26
0%
camshaft position sensor
49
1%
cargo cover on wagons
22
0%
center arm rest, release
50
1%
center hood latch, extension lever
37
1%
control arm
113
2%
coolant expansion tank, cap
112
2%
coolant hoses and clamps
91
1%
crank seal
23
0%
crank sensor
11
0%
cruise control, linkage at the gas pedal
26
0%
cup holders
170
3%
cv boots, axles
184
3%
dash ungluing
96
1%
defroster plate
12
0%
door catch, check strap, hinge
123
2%
door lock actuator
100
2%
door panel ungluing
122
2%
door-lock switch
54
1%
driveshaft
41
1%
ECC electronic climate control
46
1%
ECT engine coolant temperature sensor
54
1%
ECU air tube
34
1%
emissions air pump SAS, relay, valve
64
1%
engine mounts
213
3%
ETM
61
1%
exhaust hanger
59
1%
FPR fuel pressure regulator
10
0%
front washer pump
11
0%
fuel door latch
54
1%
fuel pump, relay
53
1%
glovebox lock
44
1%
grill retaining clips
25
0%
head gasket
24
0%
headliner ungluing
80
1%
heated seats, seat t-stat, seat wiring
70
1%
heater core, blower, resistor, lines
155
2%
IAC idle air control valve
17
0%
ignition coil, coil pack
67
1%
ignition switch, cylinder
50
1%
interior light dimmer
9
0%
interior switch, info switch
24
0%
keyless entry, remote or car
64
1%
MAF mass airflow sensor
123
2%
odometer gear
109
2%
outdoor temperature sensor
16
0%
parking brake cable
68
1%
PCV system
179
3%
PNP switch
40
1%
power antenna, cable
83
1%
power door locks
53
1%
power steering pump
18
0%
power steering rack
43
1%
power window module
27
0%
power window motor
20
0%
power window switch
75
1%
radiator
144
2%
radio, cd changer
58
1%
rear hatch latch
35
1%
rear main seal
47
1%
rear washer pump
42
1%
seat adjustment switch
33
1%
seat belt release
36
1%
seat cable
20
0%
seat leather, cloth surface
133
2%
shift solenoid
16
0%
shift-lock microswitch
40
1%
signal flasher relay
9
0%
speakers, speaker wires
63
1%
spring seats
67
1%
starter
40
1%
steering wheel
15
0%
strut mount
136
2%
sun visors
52
1%
sunroof
43
1%
sway bar link, end link, tie rod
152
2%
tailgate or trunk strut
126
2%
thermostat
101
2%
throttle control linkage
9
0%
timing cover seal
7
0%
transmission
42
1%
turbo oil cooler line, oil return, gasket, o-ring
69
1%
vacuum lines, elbows
145
2%
wheel bearing
93
1%
windshield washer tank
20
0%
windshield wiper arm, post
48
1%
 
Total votes: 6508
madspeed50
Posts: 157
Joined: 01 Aug 2012, 17:50
Year and Model: 1998 S70 T5m
Location: PA

Post by madspeed50 »

air conditioning needs a charge every few months
Top
madspeed50
Posts: 157
Joined: 01 Aug 2012, 17:50
Year and Model: 1998 S70 T5m
Location: PA

Post by madspeed50 »

auto temp control, yeah right
Top
s70fanman
Posts: 14
Joined: 24 Sep 2012, 10:37
Year and Model: 1998 s70 t5
Location: Gresham, Oregon

Post by s70fanman »

The failures are multiple, fuel pump relay, battery, fuel pump, heater core, the list goes on and on. My biggest problem is that I LOVE THE CAR!!!!!
Top
agoia
Posts: 4
Joined: 02 Apr 2007, 01:52
Year and Model: 1999 V70
Location:

Post by agoia »

This was a very depressing poll to fill out.
99 V70 vanilla
Top
tim99v70
Posts: 7
Joined: 01 Jun 2013, 09:58
Year and Model: 99 v70
Location: connecticut

Post by tim99v70 »

just replaced throttle control body bought from xemodex on my 99 v70 car still runs very rough and is in limp home mode any advice will be extremely helpful
Top
Ben850
Posts: 1613
Joined: 08 Sep 2011, 13:53
Year and Model: 1996 850 R Wagon
Location: Michigan
Been thanked: 7 times

Post by Ben850 »

O2 sensors on both cars. I think it's a given after 100k miles. Lesson learned.
1993 850 GLT , You wouldn't know it.
1996 850 Turbo Wagon White.
1995 T-5R Black. New work in progress.
1998 V70 XC Cross Country White.
1994 850 N/A Wagon Black.
1997 850 Sedan Black.
1996 850R Wagon White.
1997 850 Sedan Red ( not white or black!)
Top
cjbmustang
Posts: 100
Joined: 19 Sep 2008, 08:45
Year and Model: 1998 Volvo S70 T5
Location: Springfield, MA

Post by cjbmustang »

i had about 90% of that list checked off. more things have broken than the ones that haven't :shock:
Top
CountryBum-kin
Posts: 85
Joined: 06 Jan 2011, 15:11
Year and Model: S60 2002
Location: Indiana

Post by CountryBum-kin »

Define "FAILED by Defect" versus "FAILED by LACK of PROPER MAINTENANCE"?
Top
iceracer
Posts: 16
Joined: 18 Sep 2009, 13:55
Year and Model: v 70 1998 N/A
Location: Toronto, Ontario, Canada

Post by iceracer »

I wonder how the volvos stack up against other cars of like vintage regarding a similar list?
Although I voted on the poll, I hope I did not jinx myself by doing so....
Top
User avatar
abscate
MVS Moderator
Posts: 36145
Joined: 17 Feb 2013, 17:54
Year and Model: 99: V70s S70s,05 V70
Location: Port Jefferson Long Island NY
Has thanked: 1609 times
Been thanked: 4065 times

Post by abscate »

I'm feeling compelled to go and change my brake booster check valve because it looks so lonely with I votes
Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 XC90-in-Red
Link to Maintenance record thread
Top
Post Reply
  • Similar Topics
    Replies
    Views
    Last post

Return to “850, S70, V70, C70, V70-XC 1992-2000”