Login Register

What has failed on your 1992-2000 FWD or AWD Volvo?

Post Reply

What has failed on your 1992-2000 FWD or AWD Volvo?

02 sensor
150
2%
a/c clutch, compressor, accumulator tank
89
1%
a/c evaporator, purge valve, pressure switch
54
1%
a/c receiver-drier
21
0%
ABS module
246
4%
airguide, skidplate
63
1%
alarm status indicator
13
0%
alternator
80
1%
ball joints
142
2%
battery cable
43
1%
bevel gear
19
0%
brake booster check valve
5
0%
brake caliper
84
1%
brake hoses
54
1%
cabin temperature sensor
26
0%
camshaft position sensor
49
1%
cargo cover on wagons
22
0%
center arm rest, release
50
1%
center hood latch, extension lever
37
1%
control arm
113
2%
coolant expansion tank, cap
112
2%
coolant hoses and clamps
91
1%
crank seal
23
0%
crank sensor
11
0%
cruise control, linkage at the gas pedal
26
0%
cup holders
170
3%
cv boots, axles
184
3%
dash ungluing
96
1%
defroster plate
12
0%
door catch, check strap, hinge
123
2%
door lock actuator
100
2%
door panel ungluing
122
2%
door-lock switch
54
1%
driveshaft
41
1%
ECC electronic climate control
46
1%
ECT engine coolant temperature sensor
54
1%
ECU air tube
34
1%
emissions air pump SAS, relay, valve
64
1%
engine mounts
213
3%
ETM
61
1%
exhaust hanger
59
1%
FPR fuel pressure regulator
10
0%
front washer pump
11
0%
fuel door latch
54
1%
fuel pump, relay
53
1%
glovebox lock
44
1%
grill retaining clips
25
0%
head gasket
24
0%
headliner ungluing
80
1%
heated seats, seat t-stat, seat wiring
70
1%
heater core, blower, resistor, lines
155
2%
IAC idle air control valve
17
0%
ignition coil, coil pack
67
1%
ignition switch, cylinder
50
1%
interior light dimmer
9
0%
interior switch, info switch
24
0%
keyless entry, remote or car
64
1%
MAF mass airflow sensor
123
2%
odometer gear
109
2%
outdoor temperature sensor
16
0%
parking brake cable
68
1%
PCV system
179
3%
PNP switch
40
1%
power antenna, cable
83
1%
power door locks
53
1%
power steering pump
18
0%
power steering rack
43
1%
power window module
27
0%
power window motor
20
0%
power window switch
75
1%
radiator
144
2%
radio, cd changer
58
1%
rear hatch latch
35
1%
rear main seal
47
1%
rear washer pump
42
1%
seat adjustment switch
33
1%
seat belt release
36
1%
seat cable
20
0%
seat leather, cloth surface
133
2%
shift solenoid
16
0%
shift-lock microswitch
40
1%
signal flasher relay
9
0%
speakers, speaker wires
63
1%
spring seats
67
1%
starter
40
1%
steering wheel
15
0%
strut mount
136
2%
sun visors
52
1%
sunroof
43
1%
sway bar link, end link, tie rod
152
2%
tailgate or trunk strut
126
2%
thermostat
101
2%
throttle control linkage
9
0%
timing cover seal
7
0%
transmission
42
1%
turbo oil cooler line, oil return, gasket, o-ring
69
1%
vacuum lines, elbows
145
2%
wheel bearing
93
1%
windshield washer tank
20
0%
windshield wiper arm, post
48
1%
 
Total votes: 6508
User avatar
matthew1
Site Admin
Posts: 14801
Joined: 14 Sep 2002, 11:03
Year and Model: 850 T5, 1997
Location: Denver, Colorado, US
Has thanked: 2856 times
Been thanked: 1332 times
Contact:
Contact matthew1
..

Post by matthew1 »

Unstickying this and tucking it inside Links to MAJOR forum topics - 850, S70, V70, C70 & V70-XC to keep the top of the topic list from growing too tall. That will remain at the top of the forum.
Help keep MVS on the web -> click sponsors' links here on MVS when you buy from them.

Also -> Amazon link. Click that when you go to buy something on Amazon and MVS gets a cut!

1998 V70, no dash lights on

1997 850 T5 [gone] w/ MSD ignition coil, Hallman manual boost controller, injectors, R bumper, OMP strut brace

2004 V70 R [gone]

How to Thank someone for their post

Image
Top
maxophone
Posts: 1
Joined: 11 Mar 2014, 01:30
Year and Model: 850 Turbo 1996
Location: Chicago, IL

Post by maxophone »

Flex Pipe
on my 1996 850 Turbo Wagon has a gaping hole on top that spews exhaust toward the cabin air intake x.x
Top
ssalak
Posts: 6
Joined: 07 Jul 2009, 07:56
Year and Model: s70, 98
Location: Bloomington, IN

Post by ssalak »

MAF sensor on my 1998 S70 failed.
Top
ssalak
Posts: 6
Joined: 07 Jul 2009, 07:56
Year and Model: s70, 98
Location: Bloomington, IN

Post by ssalak »

thermostat on my 1998 S70 failed
Top
precopster
Posts: 7543
Joined: 21 Aug 2010, 00:20
Year and Model: Lots
Location: Melbourne Australia
Has thanked: 8 times
Been thanked: 128 times

Post by precopster »

B4 servo cover failed on my 2000 V70 non turbo (P80) causing 2nd-3rd gear flaring

Replacing it solved most of the shift problems though solenoids are sticking causing occasional bumping when downshifting.
Current cars VW Transporter 2.5TDI, 2010 XC90 D5 R Design
Top
nielstroll
Posts: 7
Joined: 17 Jul 2011, 07:16
Year and Model: V70 1998
Location: netherlands

Post by nielstroll »

Guys, when I approached the forum on my ABS failure, the responses (ABS module, sensors, damaged tooth cam) were all tested and found to be ok, or not to be responsible. The problem however, remained. Only last week did the computer identify a hydraulic pump failure as a possible new cause. Tested the pump, found it ok. Last remaining option: the printed circuit board controlling its action. Lo and behold, two failed solder connections have nagged me for a few years. As a possible reason for the failure an overheated hydraulic pump was mooted. All problems now gone, speedo and odo, as well as cruise control all working fine again. Thought I would let you guys know.
Top
850n00b
Posts: 20
Joined: 24 Jan 2014, 12:23
Year and Model: 95 850 98 V70
Location: Auburn

Post by 850n00b »

95 850 - Climate Control sensor sometimes goes nuts, ABS ring on passenger side CV Axle came loose causing all sorts of ABS issues, Leaking radiator and oil cooler lines.

98 V70 - Rear/side defrosters don't work, steering rack showing signs of going bad, driver seat seams coming undone from alcantara/leather. Oh, and the whole it doesn't run when in closed loop mode.
98 V70 SE T5 - ARD Green Stg2|Bosch Blues|FSDs|IPD Blues|Volans
95 850 Turbo - Daily/Beater/Workhorse
Top
User avatar
FLXC90
Posts: 1132
Joined: 18 Aug 2014, 16:31
Year and Model: 98 V70 T5
Location: Florida Panhandle
Has thanked: 16 times
Been thanked: 45 times

Post by FLXC90 »

#1 failed item on my 92-200 Volvo: Previous owner(s) :lol:
Current Volvos:
1998 V70 T5, 112k sat 5 years, still in mechanical coma (finally at the top of the pile )
2004 XC90 T6 AWD: 186k, 60 on transaxle ( traded in )
1998 POS70 N/A: DD/training aid, 236k but really about 240k, I think...ABS module( passed on to son who sold it)
Top
joe_pinehill
Posts: 208
Joined: 30 Sep 2013, 18:43
Year and Model: 850 1996
Location: United States

Post by joe_pinehill »

This tells me these are very very reliable cars. (knock wood)
96 850 GLT
RIP '90 240 DL, 285K, someone ran a stop sign in front of me
RIP '89 760 Wagon, 200K
RIP '83 240 Wagon, rusted out
Top
User avatar
charleskennedy23
Posts: 127
Joined: 11 Nov 2014, 08:07
Year and Model: 1998 V70 T5
Location: Jacksonville, FL

Post by charleskennedy23 »

Rear shocks and front struts...
Charles Kennedy
"HAGRID": Black '98 Volvo V70 T5
Top
Post Reply
  • Similar Topics
    Replies
    Views
    Last post

Return to “850, S70, V70, C70, V70-XC 1992-2000”