IPD sale XeMODeX - Experts in Volvo Electronics
Did you know? 🤔
Logged in users can get email notification of topic replies Log in or register (free).
Amazon Link Buy your stuff using this and it helps MVS!

Door lock problems

Help, Advice and DIY Tutorials on Volvo's extremely popular car line -- Volvo's 1990s "bread and butter" cars -- powered by the ubiquitous and durable Volvo inline 5-cylinder engine.

1992 - 1997 850, 850 R, 850 T5-R, 850 T5, 850 GLT
1997 - 2000 S70, S70 AWD
1997 - 2000 V70, V70 AWD
1997 - 2000 V70-XC
1997 - 2004 C70

User avatar
erikv11
Posts: 9365
Joined: Sat Jul 25, 2009 2:03 pm
Year and Model: 850, S/V70, 06 S60R
Location: Iowa
Has thanked: 72 times
Been thanked: 226 times
United States of America
erikv11

Re: Door lock problems

Post by erikv11 » Sun Dec 06, 2015 10:42 pm

So I do not have actual pics of the pin, I didn't take any previously when I figured it out and right now all the actuators I have in the garage have the pin broken off. But I took some pics to try to describe clearly how to figure out if the pin is broken, and where the pin is located. Keep in mind the L and R actuators are mirror images, and front and rear are slightly different (I think?):
1 unlocked.jpg
2 rotate to lock.jpg
3 locked.jpg
4 rotate to unlock.jpg
5 where is the red pin.jpg
6 red pin locatin 1.jpg
7 red pin location 2.jpg
Once somebody takes a peek inside a non-broken actuator, maybe we can complete the collection of pics with one of the pin!
You do not have the required permissions to view the files attached to this post.
These users thanked the author erikv11 for the post (total 2):
sleddriverPhilthy


'95 854 T5-R, Motronic 4.4, 185k
'96 855 NA, 140k
'98 S70 NA, 210k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 280k
'06 S60 R, 160k
gone: '96 NA 850 210k, '98 NA V70 182k

cn90
Posts: 6590
Joined: Wed Mar 31, 2010 9:54 am
Year and Model: 2004 V70 2.5T
Location: Omaha NE
Has thanked: 0
Been thanked: 109 times
United States of America
cn90

Re: Door lock problems

Post by cn90 » Mon Dec 07, 2015 7:51 am

Thanks erik!

I wonder if the "red pin" problem is repairable?
Where do we get parts to fix this?

On a related note, I found a nice video showing how to test the actuator with 12V battery as the source of power.
I note that the youtube guy switched the polarity of the wires to move the lever either up or down.





2004 V70 2.5T 100K+
2005 XC90 2.5T 110K+

User avatar
rspi
Posts: 7242
Joined: Sat Nov 05, 2011 10:40 am
Year and Model: 850 T-5R Wagon
Location: Albuquerque, NM
Has thanked: 18 times
Been thanked: 38 times
United States of America
rspi

Re: Door lock problems

Post by rspi » Mon Dec 07, 2015 2:15 pm

The problem is that is may work once or twice. When they are hot, from sitting in the sun or something, then they fail.



'95 855 T-5R M, Panther - 22/28 mpg
'98 S70 GLT, Lil' Red 25/32 mpg
--------------------
Volvo's of past: '87 740 GLE, '79 262C Bertone, '78 264, 960's, '98 S70 GLT, '95 850 T-5R YellowVolvo Repair Videos

User avatar
erikv11
Posts: 9365
Joined: Sat Jul 25, 2009 2:03 pm
Year and Model: 850, S/V70, 06 S60R
Location: Iowa
Has thanked: 72 times
Been thanked: 226 times
United States of America
erikv11

Re: Door lock problems

Post by erikv11 » Mon Dec 07, 2015 3:28 pm

Yeah, we know about the issues with the electric motors. The question is, have you run into many broken pins?

So far it is 3/3 with broken pins for me, only of those one also had a failing motor. Well plus there is one dead actuator in my S70, don't yet know if it is the pin or the motor.


'95 854 T5-R, Motronic 4.4, 185k
'96 855 NA, 140k
'98 S70 NA, 210k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 280k
'06 S60 R, 160k
gone: '96 NA 850 210k, '98 NA V70 182k

cn90
Posts: 6590
Joined: Wed Mar 31, 2010 9:54 am
Year and Model: 2004 V70 2.5T
Location: Omaha NE
Has thanked: 0
Been thanked: 109 times
United States of America
cn90

Re: Door lock problems

Post by cn90 » Sun Jul 24, 2016 7:35 pm

So erikv11 was correct, I took my RF actuator out, removed the PTC resistor and bridged with copper wire.
Re-assembled with 3M adhesive, same issue (lock knob going down to lock but not going up).
Turned out it was the Red Plastic thingy as erikv11 posted previously.

So:

1. Live with it (any passenger would have to wait for me to lean over to unlock the door).

2. New Actuator. Bad design from factory.

PS: I wasted time rebuilding the electric motor (replacing PTC with solid copper wire, BTW use the smallest screwdriver you can find to undo the 2 small tabs on the side), so for future reference:
- Once the door panel is OFF...reconnect only the white connector to the RF lock switch to test the motor
- Place your ear next to the actuator and operate Lock/Unlock button (on the door panel) to test the electric motor. If you hear the motor spinning in BOTH directions, but the lock know ONLY going down and not UP, then the problem is the Red Plastic thingy that erikv11 said above. In that case, new actuator is the way to go. If you are brave then remove the actuator and play with the Red Plastic thingy.


2004 V70 2.5T 100K+
2005 XC90 2.5T 110K+

User avatar
sleddriver
Posts: 975
Joined: Thu Apr 08, 2010 6:06 pm
Year and Model: 1998 V70 T5
Location: Tx
Has thanked: 11 times
Been thanked: 11 times
United States of America
sleddriver

Re: Door lock problems

Post by sleddriver » Sat Feb 10, 2018 1:34 pm

erikv11 wrote:
Sun Mar 30, 2014 8:58 am
I am working on a 98 V70 where both rear doors will only lock when using the button or the key.

I inspected the actuator mechanisms and found a surprise: In both cases, the motors are working just fine. Instead, the little red pin that the mechanism pushes against to open the door, is missing (presumably broken off?) on both of them. I repaired one of them by just swapping the good motor over to an assembly with a bad motor I had in the garage. That side is working now, which confirms that the motor has no issues and the problem was just the broken plastic.

Anyway, since the first two I looked at had broken plastic but *not* motor issues, clearly this is another issue to look out for. Just wanted to post that up.
+1. Thanks for that erikv11!
Just installed a PnP lock mechanism in the pass. front door. It will easily lock the door, but not open. The motor is quite strong, it's 50°F outside, the lock doesn't work slowly either like the others I replaced a few years back.

Therefore, I suspect something is wrong with the plastic levers used to move the post up & down and release the internal cam so it can rotate and allow the door to open.


1998 V70 T5 226,808 miles. Original Owner.
M1 10W-30 HM

djekan
Posts: 12
Joined: Mon Dec 22, 2008 1:36 pm
Year and Model:
Location:
Has thanked: 0
Been thanked: 0
djekan

Re: Door lock problems

Post by djekan » Sun Sep 15, 2019 1:53 am

Hi, I've replaced the two rear lock door motors, after replace the LH side all OK, after replace the RH side the problem pop up, now the two motors only lock the latch but doesn't unlock, I've remove the motor RH to test only the LH and doesn't open now, so I tested the motor directly to the battery and it work great, revert the test wires an works in both directions... I install it and just close doesn't open, any ideas?
Thank you.



User avatar
erikv11
Posts: 9365
Joined: Sat Jul 25, 2009 2:03 pm
Year and Model: 850, S/V70, 06 S60R
Location: Iowa
Has thanked: 72 times
Been thanked: 226 times
United States of America
erikv11

Re: Door lock problems

Post by erikv11 » Sun Sep 15, 2019 7:52 am

Read the posts right above yours that discuss this exact problem in great detail, starting with the post with all the pictures with orange writing on them. Lock-but-does-not-unlock is what happens when the pin is broken, check the pin visually.


'95 854 T5-R, Motronic 4.4, 185k
'96 855 NA, 140k
'98 S70 NA, 210k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 280k
'06 S60 R, 160k
gone: '96 NA 850 210k, '98 NA V70 182k

Philthy
Posts: 5
Joined: Sat Oct 05, 2019 9:23 am
Year and Model: C70 2005
Location: Devon
Has thanked: 1 time
Been thanked: 0
Great Britain
Philthy

Re: Door lock problems

Post by Philthy » Sat Oct 05, 2019 10:37 am

Thanks to Erikv11 for this post. I have the dreaded lock, but won't unlock from the key fob, and after several hours removing the whole electric window mechanism (C70 convertible), can confirm that the pin is broken on mine. On mine though, the plastic is yellow. I knew something had broken inside the lock, when I found a small yellow piece of plastic, with the pin on it, in the bottom of the door skin. I've got one coming from ebay, and hope to get some video and pictures to help others, as it is a royal pita to remove everything from the door to remove the lock mechanism. I'm also hoping to strip the mechanism, and see if I could fabricate one up in aluminium to replace it. It appears to be a weak spot on these vehicles.
Thanks.



JimBee
Posts: 1720
Joined: Tue Dec 09, 2008 9:23 pm
Year and Model: 93 and 2 96 850's
Location: Minneapolis
Has thanked: 13 times
Been thanked: 19 times
United States of America
JimBee

Re: Door lock problems

Post by JimBee » Sat Oct 05, 2019 9:52 pm

Do any of these failures result in not being able to open the door at all?



Post Reply
  • Similar Topics
    Replies
    Views
    Last post