IPD sale XeMODeX - Experts in Volvo Electronics
Did you know? 🤔
Logged in users can get email notification of topic replies Log in or register (free).
Amazon Link Buy anything with this and it helps MVS!

Clicking driver's side door module

Help, Advice, Owners' Discussion and DIY Tutorials on Volvo's stylish, distinctive "P2" platform cars.

2001 - 2007 V70
2004 - 2007 V70 R
2001 - 2007 XC-70
2001 - 2009 S60
2003 - 2007 S60 R

mrjay62
Posts: 153
Joined: Wed May 14, 2014 7:45 am
Year and Model: V70XC 2002
Location: Plamyar Ny
Has thanked: 0
Been thanked: 3 times
United States of America
mrjay62

Re: Clicking driver's side door module

Post by mrjay62 » Mon Feb 18, 2019 5:02 pm

Ok... I had the same issues on my 02 V70 xc 1st the driver side would click for an hour or more than start working again, I pulled it, cleaned all the switch contacts seemed better for a while then the passenger door started to do it no windows no locks,no temp sensor.
I took a shot and went to a junk yard and found the same model and year I pulled both modules and installed them in my car. It's 2 months later and so far no problem. Not bad for 17$

User avatar
dlundblad
Posts: 116
Joined: Wed Apr 04, 2018 12:15 pm
Year and Model: 2002 S60 2.4t
Location: Indiana
Has thanked: 6 times
Been thanked: 3 times
United States of America
dlundblad

Re: Clicking driver's side door module

Post by dlundblad » Tue Feb 19, 2019 1:40 am

Not bad at all. Thanks for the info.
Hers: Charcoal 2002 S60 2.4t 187k

chrism
Posts: 1008
Joined: Wed Jan 28, 2009 9:38 am
Year and Model: S80 / 2005
Location: Atlanta, GA
Has thanked: 0
Been thanked: 22 times
chrism

Re: Clicking driver's side door module

Post by chrism » Tue Feb 19, 2019 9:43 am

Here are a couple links to previous DDM problem posts. One even describes the clicking and battery going dead:

viewtopic.php?t=26624

viewtopic.php?t=23510

If there is a a small white label stuck on the module with numbers on it, (not the part number molded into the plastic), that's the key to the castle. In my case there were three numbers on the label - the replacement module matched the first two numbers out of the three. It ended up working fine with no reprogramming required.

Jonboy74
Posts: 68
Joined: Wed Oct 05, 2011 3:17 pm
Year and Model: V70 2.4T, 2002
Location: USA - North Carolina
Has thanked: 30 times
Been thanked: 2 times
United States of America
Jonboy74

Re: Clicking driver's side door module

Post by Jonboy74 » Sat Jul 27, 2019 9:43 am

dlundblad wrote:
Tue Jan 08, 2019 4:09 am

Is the door chime silent too?
I know this is 7 months late...apologies...

Honestly, I had not given it any thought, so I just went out and checked. If the key is in the ignition, and the door is open, I get a chime. Pull the key out or close the door, and the chime stops.

Thanks,

Jonboy

mrjay62
Posts: 153
Joined: Wed May 14, 2014 7:45 am
Year and Model: V70XC 2002
Location: Plamyar Ny
Has thanked: 0
Been thanked: 3 times
United States of America
mrjay62

Re: Clicking driver's side door module

Post by mrjay62 » Sat Jul 27, 2019 4:22 pm

Best bet is to find another car same year,model. Grab them disconnect your battery and swap them... I was charged 9$ for the drivers side and 8$ for the passenger side at a U pull it yard... And it's still working! Since then I found another set and bought them ... For Just in case.
Test them before installing on to your door panel.

Good luck....

Jonboy74
Posts: 68
Joined: Wed Oct 05, 2011 3:17 pm
Year and Model: V70 2.4T, 2002
Location: USA - North Carolina
Has thanked: 30 times
Been thanked: 2 times
United States of America
Jonboy74

Re: Clicking driver's side door module

Post by Jonboy74 » Wed May 13, 2020 11:00 pm

For anyone reading this, for what it is worth....I chatted with Yagger in July of 2019 and ended up buying a replacement DDM off of ebay for under $60, matching the numbers on my module with what was on the one on ebay. Worked like a champ without any programming, and seems to have been working fine for the most part ever since. Occasionally the window seems to be stuck, but flipping the switches back and forth seems to un-stick it.

Cheers!

Jonboy

User avatar
darrylrobert
Posts: 180
Joined: Fri Mar 06, 2020 6:25 am
Year and Model: 2001 v70xc
Location: australia
Has thanked: 3 times
Been thanked: 7 times
Australia
darrylrobert

Re: Clicking driver's side door module

Post by darrylrobert » Sat May 16, 2020 7:41 am

I had the same issue, i tried replacing the little relay in the module but it kept playing up. Ended up buying a replacement online and that fixed it.
Sometimes when i press auto down either window will get about half way down stop and go back up, might be getting stuck or might need to re learn where up and sown is..not sure

Post Reply
  • Similar Topics
    Replies
    Views
    Last post