IPD sale XeMODeX - Experts in Volvo Electronics
Did you know? 🤔
Logged in users can get email notification of topic replies Log in or register (free).
Amazon Link Buy your stuff using this and it helps MVS!

2001 s60 intermittent crank no start ECM-2400 [Bad wire ECM to CEM] Topic is solved

Help, Advice, Owners' Discussion and DIY Tutorials on Volvo's stylish, distinctive "P2" platform cars.

2001 - 2007 V70
2004 - 2007 V70 R
2001 - 2007 XC-70
2001 - 2009 S60
2003 - 2007 S60 R

goldmandan
Posts: 244
Joined: Wed Jun 05, 2013 8:27 pm
Year and Model: 1999 S 70, 2000 V70
Location: Florida
Has thanked: 0
Been thanked: 1 time
Sweden
goldmandan

Re: 2001 s60 intermittent crank no start ECM-2400, bad wire ECM to CEM

Post by goldmandan » Sun Jun 16, 2019 7:23 pm

I did buy a new fuel pump relay but have not checked the cicuit or replaced it yet



goldmandan
Posts: 244
Joined: Wed Jun 05, 2013 8:27 pm
Year and Model: 1999 S 70, 2000 V70
Location: Florida
Has thanked: 0
Been thanked: 1 time
Sweden
goldmandan

Re: 2001 s60 intermittent crank no start

Post by goldmandan » Fri Jul 12, 2019 5:42 am

OK, there is a solution to this madness!!!!! There was a loose cable at the ECM!! Now with it back in place the car starts every time!!! What a crazy thing but the code ECM2400 said to check wire from ECM to CEM. When doing this i found a loose wire!



User avatar
abscate
MVS Moderator
Posts: 18802
Joined: Sun Feb 17, 2013 5:54 pm
Year and Model: 99T5 ,99S70,2005V70
Location: NYC, ALBANY NY
Has thanked: 221 times
Been thanked: 729 times
Trinidad & Tobago
abscate

Re: 2001 s60 intermittent crank no start

Post by abscate » Fri Jul 12, 2019 7:18 pm

Volvo Horns to Rick back in April!!
Are the other codes all ECM-XXXX?

Check the wiring to the fuel pump relay.

ECM-2400 Fuel pump (FP) relay. Signal too high or too low. Permanent fault

Possible source
Signal too high:
short-circuit to supply voltage in the signal cable
Signal too low:
short-circuit to ground in the signal cable
open-circuit in the signal cable


Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 BMW

User avatar
abscate
MVS Moderator
Posts: 18802
Joined: Sun Feb 17, 2013 5:54 pm
Year and Model: 99T5 ,99S70,2005V70
Location: NYC, ALBANY NY
Has thanked: 221 times
Been thanked: 729 times
Trinidad & Tobago
abscate

Re: 2001 s60 intermittent crank no start ECM-2400 [Bad wire ECM to CEM]

Post by abscate » Fri Jul 12, 2019 7:20 pm

Added code and solution to title for search


Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 BMW

goldmandan
Posts: 244
Joined: Wed Jun 05, 2013 8:27 pm
Year and Model: 1999 S 70, 2000 V70
Location: Florida
Has thanked: 0
Been thanked: 1 time
Sweden
goldmandan

Re: 2001 s60 intermittent crank no start ECM-2400 [Bad wire ECM to CEM]

Post by goldmandan » Fri Jul 12, 2019 8:38 pm

Very good! There was a lot of other intermittent stupidity going on also so I figured it was because the car had been sitting here in the FL heat/moisture. Removed ECM, sprayed contact cleaner and waited a few mins for it to dry and then assembled again. CAr runs like new now again!



goldmandan
Posts: 244
Joined: Wed Jun 05, 2013 8:27 pm
Year and Model: 1999 S 70, 2000 V70
Location: Florida
Has thanked: 0
Been thanked: 1 time
Sweden
goldmandan

Re: 2001 s60 intermittent crank no start ECM-2400 [Bad wire ECM to CEM]

Post by goldmandan » Mon Aug 05, 2019 7:51 am

back to the same problem......... i want to know which modules are "married" with the VIN? I know the CEM and ECM. I have a 2003 S60 also which runs and starts up all the time..... would like to swap ECM and CEM from that one into the 2001 and see if it will stop the problem. If so I can send the CEM to be rebuilt and be done with this mystery nightmare!



Post Reply