Get email notification of topic replies. Log in or register (free). Amazon Link Buy anything with this and it helps MVS!
Anyone else have issues with excess oil consumption? (S60 2013)
Anyone else have issues with excess oil consumption? (S60 2013)
In the past 8 months I’ve needed oil changes every 1000-2000 miles. My low pressure oil light would come on. I’d take it to my local pep boys and they’d refill it. Twice for free because they felt bad. Finally went to the dealer today and this is an issue with some models. It either needs a new engine or piston rods(rings?). Unfortunately in order to have my warranty cover it I have to start from square one and bring my car to the dealer every 500 miles so they can properly document my oil levels. I had all of my previous receipts from oil changes but since it was never documented that the oil was low there is no proof of excess oil burning. Anyone have experience with this or had it fixed? I’m hoping after 3 months of proper documentation i will have a good case to prove the repair is needed.
- oragex
- Posts: 5204
- Joined: Fri May 24, 2013 6:20 am
- Year and Model: S60 2003
- Location: Canada
- Has thanked: 102 times
- Been thanked: 321 times
- Contact:
Re: Anyone else have issues with excess oil consumption? (S60 2013)
Not the right section of the forum - the section here is for 2001-2009, but yes, it was a widespread issue with the 2012-up engines, caused by a faulty breather (PCV) unit, I believe the unit is easy to replace however, if left without being replaced it may damage the pistons (and rings) so the pistons will indeed need replaced as well - costly. Volvo took care of most of the cars still under warranty. Normally the dealer has indeed to survey the oil level over a period of time, then make a decision. This same PCV defective part was used on other european cars such as Audi and Bmw, my parents Q5 had the same problem, the Audi dealer documented the oil consumption the same way and had it fixed.
A few links https://forums.swedespeed.com/showthrea ... No-Warning
https://forums.swedespeed.com/showthrea ... Experience
A few links https://forums.swedespeed.com/showthrea ... No-Warning
https://forums.swedespeed.com/showthrea ... Experience
Several Volvo Repair Videos https://www.youtube.com/playlist?list=P ... s0FSVSOT_c
- abscate
- MVS Moderator
- Posts: 23681
- Joined: Sun Feb 17, 2013 5:54 pm
- Year and Model: 99T5 ,99S70,2005V70
- Location: NYC, ALBANY NY
- Has thanked: 439 times
- Been thanked: 1330 times
Re: Anyone else have issues with excess oil consumption? (S60 2013)
If you run the engine until the oil pressure light comes on, you won’t get a warranty claim repair.
That would classify as abuse.
That would classify as abuse.
Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 BMW
Link to Maintenance record thread
Link To Volvo Glossary
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 BMW
Link to Maintenance record thread
Link To Volvo Glossary
- erikv11
- Posts: 10124
- Joined: Sat Jul 25, 2009 2:03 pm
- Year and Model: 850, V70, S60R, XC70
- Location: Iowa
- Has thanked: 129 times
- Been thanked: 362 times
Re: Anyone else have issues with excess oil consumption? (S60 2013)
I had to delete my reply three times, I give up. This is sarcasm from abscate, right?
'95 854 T5-R, Motronic 4.4, 185k
'96 855 NA, 145k
'98 S70 NA, 220k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 293k
'06 S60 R, 167k
'07 XC70, 170k
'99 Camry V6
130k
gone: '96 NA 850 210k, '98 NA V70 182k
'96 855 NA, 145k
'98 S70 NA, 220k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 293k
'06 S60 R, 167k
'07 XC70, 170k
'99 Camry V6

gone: '96 NA 850 210k, '98 NA V70 182k
- abscate
- MVS Moderator
- Posts: 23681
- Joined: Sun Feb 17, 2013 5:54 pm
- Year and Model: 99T5 ,99S70,2005V70
- Location: NYC, ALBANY NY
- Has thanked: 439 times
- Been thanked: 1330 times
Re: Anyone else have issues with excess oil consumption? (S60 2013)
I’m a bit worried OP has a leak and essentially is just running out of oil. I don’t think you can internally burn 3-4 quarts of oil in 1000-2000 miles without some impressive external symptoms.
Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 BMW
Link to Maintenance record thread
Link To Volvo Glossary
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 BMW
Link to Maintenance record thread
Link To Volvo Glossary
- erikv11
- Posts: 10124
- Joined: Sat Jul 25, 2009 2:03 pm
- Year and Model: 850, V70, S60R, XC70
- Location: Iowa
- Has thanked: 129 times
- Been thanked: 362 times
Re: Anyone else have issues with excess oil consumption? (S60 2013)
Haha - and I was thinking there is no way you can leak 3-4 quarts of oil in 1000-2000 miles without some impressive external symptoms (oil all over the driveway, garage, back of the car ... ).
'95 854 T5-R, Motronic 4.4, 185k
'96 855 NA, 145k
'98 S70 NA, 220k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 293k
'06 S60 R, 167k
'07 XC70, 170k
'99 Camry V6
130k
gone: '96 NA 850 210k, '98 NA V70 182k
'96 855 NA, 145k
'98 S70 NA, 220k (living out west)
'98 V70, T5 tune-injectors-turbo, LPT engine, 293k
'06 S60 R, 167k
'07 XC70, 170k
'99 Camry V6

gone: '96 NA 850 210k, '98 NA V70 182k
-
- Similar Topics
- Replies
- Views
- Last post
-
- 23 Replies
- 661 Views
-
Last post by oragex
-
- 16 Replies
- 4693 Views
-
Last post by KnucklesBusted
-
- 2 Replies
- 285 Views
-
Last post by BlackThunder