Cookeh wrote: ↑11 Sep 2020, 13:19 but they have a different Bosch part numbers (0232 101 030) - are they compatible?

0232 101 030 is the Bosch catalog part number for 1996 850 2.3l L5.

Embedded images are back.

Editor working.

So far I don't see anything that warrants concern. Measure the battery voltage after a 30 minute rest. Post the measurement. Alternator range is 13.5V - 14.5V. The Alternator voltage will drop to 13.5V when the battery is fully charged. Keep in mind the voltmeter might be a little off or there might...

slickdizzy wrote: ↑22 Sep 2020, 20:11 This car was clearly the victim of a non-Volvo mechanic who troubleshot symptoms, not causes. Nonetheless, I was a little disappointed to see they didn't even drive the replacement seal in straight.

Is this the perpetrator?

Most likely the SWM (Steering Wheel Module) it has the steering column stalks sticking out of it (Turn Signal, Wipers .. ect). About $16.00 at a PNP and 1/2 hour of labor to change it when you know what you are doing. Figure an hour the first time through. You will need to disconnect the battery and...

Good chance it is ISS World Wide Web Publishing Service hogging port 80. Uninstall it if it is installed or disable it in Windows services.

Then once smooth and dry, I will install a green Volvo gasket with an Aisin water pump. Fingers crossed. It looks like you got JB on the threads ... not good. If you have some Acetone. Do this before it dries up. Dampen, not sopping wet, dampen a rag with the Acetone and wipe off any excess JB Weld...

wbrenegade420 wrote: ↑28 Sep 2020, 23:42 Cleaned stud threads with pure acetone. Threads are nice, clean and shiny now!! Thanks again for the warning.

Good news ... hope you got the mating surface while you where at it.

Any insight would be greatly appreciated I really don't want to scrap it You can use any turbocharged RN engine. The '98 Intake manifold will not transfer to a RNC engine. RN and RNC Intakes have different bolt patterns The compression ratio is too high on Naturally Aspirated engines for the turboc...

Check list. 1. Fuel filter. 2. Fuel Pump Control Module wiring and connectors. 3. Fuel Pump Fuel Pump wiring and connectors . 4. Fuel pressure sensor wiring and connectors. 5. Fuel pressure sensor. 6. Fuel Pump Control Module. 7. Fuel Pump. ECM-290B ( P0090 ) Fuel pressure. Diagnostic trouble code (...