Login Register

Trying to locate RMS area on 850...

Help, Advice and DIY Tutorials on Volvo's P80 platform cars -- Volvo's 1990s "bread and butter" cars -- powered by the ubiquitous and durable Volvo inline 5-cylinder engine.

1992 - 1997 850, including 850 R, 850 T-5R, 850 T-5, 850 GLT
1997 - 2000 S70, S70 AWD
1997 - 2000 V70, V70 AWD
1997 - 2000 V70-XC
1997 - 2004 C70

Post Reply
plumsmooth
Posts: 218
Joined: 17 January 2015
Year and Model: V70 Wagon 2004
Location: Johnson Vermont

Trying to locate RMS area on 850...

Post by plumsmooth »

I have scoured Google images checked my Haynes manual and started to look for diagrams or anything.
But I can not see any pictures other than the Rear Main Seal exposed up close.

I am trying to visualize and also I am trying to pay attention due to paranoia from recent Intake Cam seal and possible Exhaust Cam Seal leaks...

I have read RMS can be mistook for the Cam seals but what about the other way around.

I was please hoping someone could identify what to look for when trying to visually inspect for RMS leak?

Maybe even the position on the ground if oil is making it that far?

I am currently monitoring a little oil around and what was directly on top of my Exhaust Cam Seal after a mechanic recently glued back my Intake Cam Seal.

Thanks you very much for your time...

precopster
Posts: 7543
Joined: 21 August 2010
Year and Model: Lots
Location: Melbourne Australia
Has thanked: 8 times
Been thanked: 128 times

Post by precopster »

Engine oil which weeps from the small rectangular hole at the union between the transmission and the engine. As this point is very low and gravity can carry oil from almost any leak to the same position it is almost impossible to distinguish from other leaks if they are present.

Best is to eliminate all other leaks then clean the engine and take small drives then re- inspect. If the oil appears only at the weep hole I mentioned it is likely an RMS leak. If there's a trail of oil or fluid leading to weep hole it's likely that there is a leak from a different source.

RMS has been removed from this engine which has also had the lower crankcase half removed. It would be at the base of this picture. Image
Current cars VW Transporter 2.5TDI, 2010 XC90 D5 R Design

plumsmooth
Posts: 218
Joined: 17 January 2015
Year and Model: V70 Wagon 2004
Location: Johnson Vermont

Post by plumsmooth »

Well If I see a leak at the Cam sensor I think I can currently rule out RMS unless they are both present...

Anyway currently when I look down into the front compartment, I am imagining that RMS being between the engine and transmission directly below another few inches.

So I realize RMS leak can not be spotted from above...

Ozark Lee
MVS Moderator
Posts: 14798
Joined: 7 September 2006
Year and Model: Many Volvos
Location: USA Midwest
Has thanked: 4 times
Been thanked: 75 times

Post by Ozark Lee »

You can't see it until the transmission is removed. It is the thin black seal surrounding the end of the crankshaft in this picture.
Volvo April 29 022.JPG
That was just after I replaced it which is why there is some residual oil in that picture. The oil dripped out when I removed the old one.

...Lee
'94 850 N/A 5 speed
'96 Platinum Edition Turbo
Previous:
1999 V70XC - Nautic Blue - Totaled while parked.
1999 V70XC - RIP - Wrecked Parts Car.
1998 S70 T5
1996 850 N/A
1989 740 GLT
1986 740 GLT
1972 142 Grand Luxe

Post Reply
  • Similar Topics
    Replies
    Views
    Last post