As I have posted here before, I just completed the two week installation of a new fuel pump. My first step was to see if I could develop fuel pressure, this I did by attempting to start the motor. There was no sign on my pressure gauge, so I cranked it, hoping to start, about 5 times. On the fifth try, all electricity suddenly failed, completely and totally. There were no longer lights on the dash, horn wouldn't work, etc. I believe, but cannot swear, that I saw very light smoke, similar to cigarette smoke, come out of the dash. There was no "sound of failure" that I can recall. I have nothing to test the battery with, but it appears to be dead. Is there any primary electrical connection which might cause such a total failure of electricity?
The driver's door had been left ajar; this might have drawn the battery down. However, it did crank normally several times, the loss of electricity was not gradual, it was sudden and complete.
Sudden complete electrical loss '05 V70 n/a
-
abscate
- MVS Moderator
- Posts: 35283
- Joined: 17 February 2013
- Year and Model: 99: V70s S70s,05 V70
- Location: Port Jefferson Long Island NY
- Has thanked: 1502 times
- Been thanked: 3813 times
Open up your jump cover on the fuse box under hood and inspect the primary cable coming up from the battery. Look for dark corrosion or signs of duress there.
Of course, battery connections under the trunk floor mat first.
Modern cars will crank fine but no start due to low bus voltage to the electronics.
Of course, battery connections under the trunk floor mat first.
Modern cars will crank fine but no start due to low bus voltage to the electronics.
Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 XC90-in-Red
Link to Maintenance record thread
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 XC90-in-Red
Link to Maintenance record thread
-
Faust
- Posts: 394
- Joined: 4 January 2012
- Year and Model: xc70 2008
- Location: MA
- Has thanked: 31 times
- Been thanked: 10 times
I have checked all of the connections I have found, no looseness or corrosion. I think it is important that the electricity did not reduce, it shut of like a light responding to a wall switch.
2004 V70
1964 Plymouth Convert (small block)
1967 Dodge Coronet (big block)
1964 Plymouth Convert (small block)
1967 Dodge Coronet (big block)
-
Faust
- Posts: 394
- Joined: 4 January 2012
- Year and Model: xc70 2008
- Location: MA
- Has thanked: 31 times
- Been thanked: 10 times
Ignition switch sounds very plausible, embarrassed I didn't think of it. I have a parts car, I'll switch it tomorrow. Other suggestions still welcome.
2004 V70
1964 Plymouth Convert (small block)
1967 Dodge Coronet (big block)
1964 Plymouth Convert (small block)
1967 Dodge Coronet (big block)
-
firstv70volvo
- Posts: 574
- Joined: 6 March 2010
- Year and Model: V70 T5 2001
- Location: Sacramento, CA
- Has thanked: 52 times
- Been thanked: 123 times
There are some heavy-duty fuses near the battery, 40-50 amp fuses, 11E/4 and 11E/5 supply the CEM, I'd check these fuses.
-
volvolugnut
- Posts: 6229
- Joined: 19 January 2014
- Year and Model: 2001 V70
- Location: Oklahoma USA
- Has thanked: 927 times
- Been thanked: 1000 times
I think first effort is to get a fully charged battery installed. Nothing good to test unless you have about 12.5 volts available.
volvolugnut
volvolugnut
The Fleet:
Volvo: 2001 V70 T5, 1986 244DL, 1983 245DL, 1975 245DL, 1959 PV544, multiple Volvo parts cars.
Mercedes: 2001 E320, 1973 280, 1974 280C, 1989 300E, 1988 300TE, 1979 300TD, parts cars.
2009 Smart Passion
Ford: 1977 F350, 1964 F150 (2), 1938 Tudor Sedan
Farmall tractors: 1956 400 Diesel, 1946 A
And others.
Volvo: 2001 V70 T5, 1986 244DL, 1983 245DL, 1975 245DL, 1959 PV544, multiple Volvo parts cars.
Mercedes: 2001 E320, 1973 280, 1974 280C, 1989 300E, 1988 300TE, 1979 300TD, parts cars.
2009 Smart Passion
Ford: 1977 F350, 1964 F150 (2), 1938 Tudor Sedan
Farmall tractors: 1956 400 Diesel, 1946 A
And others.
-
Faust
- Posts: 394
- Joined: 4 January 2012
- Year and Model: xc70 2008
- Location: MA
- Has thanked: 31 times
- Been thanked: 10 times
That was in fact the problem, I am truly embarrassed not to have thought of it, particularly since I was operating the switch when everything failed. My thanks to all who responded.
Now that I have electricity again, I can continue my three week project of attempting to pump fuel from the tank to the engine.
2004 V70
1964 Plymouth Convert (small block)
1967 Dodge Coronet (big block)
1964 Plymouth Convert (small block)
1967 Dodge Coronet (big block)
-
- Similar Topics
- Replies
- Views
- Last post