Login Register

What has failed on your 1992-2000 FWD or AWD Volvo?

Help, Advice and DIY Tutorials on Volvo's P80 platform cars -- Volvo's 1990s "bread and butter" cars -- powered by the ubiquitous and durable Volvo inline 5-cylinder engine.

1992 - 1997 850, including 850 R, 850 T-5R, 850 T-5, 850 GLT
1997 - 2000 S70, S70 AWD
1997 - 2000 V70, V70 AWD
1997 - 2000 V70-XC
1997 - 2004 C70
Post Reply

What has failed on your 1992-2000 FWD or AWD Volvo?

02 sensor
149
2%
a/c clutch, compressor, accumulator tank
89
1%
a/c evaporator, purge valve, pressure switch
54
1%
a/c receiver-drier
21
0%
ABS module
245
4%
airguide, skidplate
62
1%
alarm status indicator
13
0%
alternator
80
1%
ball joints
142
2%
battery cable
43
1%
bevel gear
19
0%
brake booster check valve
5
0%
brake caliper
83
1%
brake hoses
53
1%
cabin temperature sensor
26
0%
camshaft position sensor
49
1%
cargo cover on wagons
21
0%
center arm rest, release
50
1%
center hood latch, extension lever
36
1%
control arm
113
2%
coolant expansion tank, cap
111
2%
coolant hoses and clamps
91
1%
crank seal
23
0%
crank sensor
10
0%
cruise control, linkage at the gas pedal
26
0%
cup holders
168
3%
cv boots, axles
183
3%
dash ungluing
96
1%
defroster plate
12
0%
door catch, check strap, hinge
122
2%
door lock actuator
100
2%
door panel ungluing
120
2%
door-lock switch
54
1%
driveshaft
41
1%
ECC electronic climate control
46
1%
ECT engine coolant temperature sensor
53
1%
ECU air tube
34
1%
emissions air pump SAS, relay, valve
63
1%
engine mounts
211
3%
ETM
61
1%
exhaust hanger
58
1%
FPR fuel pressure regulator
10
0%
front washer pump
11
0%
fuel door latch
53
1%
fuel pump, relay
52
1%
glovebox lock
44
1%
grill retaining clips
25
0%
head gasket
24
0%
headliner ungluing
79
1%
heated seats, seat t-stat, seat wiring
70
1%
heater core, blower, resistor, lines
155
2%
IAC idle air control valve
17
0%
ignition coil, coil pack
66
1%
ignition switch, cylinder
50
1%
interior light dimmer
9
0%
interior switch, info switch
23
0%
keyless entry, remote or car
64
1%
MAF mass airflow sensor
123
2%
odometer gear
109
2%
outdoor temperature sensor
16
0%
parking brake cable
66
1%
PCV system
178
3%
PNP switch
40
1%
power antenna, cable
82
1%
power door locks
52
1%
power steering pump
17
0%
power steering rack
42
1%
power window module
27
0%
power window motor
19
0%
power window switch
74
1%
radiator
143
2%
radio, cd changer
57
1%
rear hatch latch
34
1%
rear main seal
47
1%
rear washer pump
42
1%
seat adjustment switch
32
0%
seat belt release
36
1%
seat cable
20
0%
seat leather, cloth surface
132
2%
shift solenoid
16
0%
shift-lock microswitch
40
1%
signal flasher relay
9
0%
speakers, speaker wires
62
1%
spring seats
66
1%
starter
40
1%
steering wheel
15
0%
strut mount
135
2%
sun visors
52
1%
sunroof
42
1%
sway bar link, end link, tie rod
151
2%
tailgate or trunk strut
124
2%
thermostat
100
2%
throttle control linkage
9
0%
timing cover seal
7
0%
transmission
42
1%
turbo oil cooler line, oil return, gasket, o-ring
69
1%
vacuum lines, elbows
142
2%
wheel bearing
93
1%
windshield washer tank
20
0%
windshield wiper arm, post
48
1%
 
Total votes: 6458
madspeed50
Posts: 157
Joined: 1 August 2012
Year and Model: 1998 S70 T5m
Location: PA

Re: What has failed on your 1992-2000 FWD or AWD Volvo?

Post by madspeed50 »

air conditioning needs a charge every few months
Top
madspeed50
Posts: 157
Joined: 1 August 2012
Year and Model: 1998 S70 T5m
Location: PA

Post by madspeed50 »

auto temp control, yeah right
Top
s70fanman
Posts: 14
Joined: 24 September 2012
Year and Model: 1998 s70 t5
Location: Gresham, Oregon

Post by s70fanman »

The failures are multiple, fuel pump relay, battery, fuel pump, heater core, the list goes on and on. My biggest problem is that I LOVE THE CAR!!!!!
Top
agoia
Posts: 4
Joined: 2 April 2007
Year and Model: 1999 V70
Location:

Post by agoia »

This was a very depressing poll to fill out.
99 V70 vanilla
Top
tim99v70
Posts: 7
Joined: 1 June 2013
Year and Model: 99 v70
Location: connecticut

Post by tim99v70 »

just replaced throttle control body bought from xemodex on my 99 v70 car still runs very rough and is in limp home mode any advice will be extremely helpful
Top
Ben850
Posts: 1613
Joined: 8 September 2011
Year and Model: 1996 850 R Wagon
Location: Michigan
Been thanked: 7 times

Post by Ben850 »

O2 sensors on both cars. I think it's a given after 100k miles. Lesson learned.
1993 850 GLT , You wouldn't know it.
1996 850 Turbo Wagon White.
1995 T-5R Black. New work in progress.
1998 V70 XC Cross Country White.
1994 850 N/A Wagon Black.
1997 850 Sedan Black.
1996 850R Wagon White.
1997 850 Sedan Red ( not white or black!)
Top
cjbmustang
Posts: 100
Joined: 19 September 2008
Year and Model: 1998 Volvo S70 T5
Location: Springfield, MA

Post by cjbmustang »

i had about 90% of that list checked off. more things have broken than the ones that haven't :shock:
Top
CountryBum-kin
Posts: 85
Joined: 6 January 2011
Year and Model: S60 2002
Location: Indiana

Post by CountryBum-kin »

Define "FAILED by Defect" versus "FAILED by LACK of PROPER MAINTENANCE"?
Top
iceracer
Posts: 16
Joined: 18 September 2009
Year and Model: v 70 1998 N/A
Location: Toronto, Ontario, Canada

Post by iceracer »

I wonder how the volvos stack up against other cars of like vintage regarding a similar list?
Although I voted on the poll, I hope I did not jinx myself by doing so....
Top
User avatar
abscate
MVS Moderator
Posts: 35267
Joined: 17 February 2013
Year and Model: 99: V70s S70s,05 V70
Location: Port Jefferson Long Island NY
Has thanked: 1497 times
Been thanked: 3810 times

Post by abscate »

I'm feeling compelled to go and change my brake booster check valve because it looks so lonely with I votes
Empty Nester
A Captain in a Sea of Estrogen
1999-V70-T5M56 2005-V70-M56 1999-S70 VW T4 XC90-in-Red
Link to Maintenance record thread
Top
Post Reply
  • Similar Topics
    Replies
    Views
    Last post

Return to “850, S70, V70, C70, V70-XC 1992-2000”