Login Register

A/C Actuator Motor Calibration Shortcut Topic is solved

Help, Advice and DIY Tutorials on Volvo's P80 platform cars -- Volvo's 1990s "bread and butter" cars -- powered by the ubiquitous and durable Volvo inline 5-cylinder engine.

1992 - 1997 850, including 850 R, 850 T-5R, 850 T-5, 850 GLT
1997 - 2000 S70, S70 AWD
1997 - 2000 V70, V70 AWD
1997 - 2000 V70-XC
1997 - 2004 C70

Post Reply
JBRollo
Posts: 39
Joined: 6 October 2005
Year and Model: 2012 Volvo S60 T5
Location: Tallahassee, FL, USA

Re: A/C Actuator Motor Calibration Shortcut

Post by JBRollo »

Basically that's it. The trick is to match the setting of the old one to the new. You can do this several ways. I used a straight edge to mark the old one accurately and used the battery to move the new one to match.

CoupeC70
Posts: 29
Joined: 14 March 2019
Year and Model: C70 Coupe '01
Location: Hessen
Has thanked: 5 times

Post by CoupeC70 »

JBRollo wrote: 14 Mar 2019, 07:30 Basically that's it. The trick is to match the setting of the old one to the new. You can do this several ways. I used a straight edge to mark the old one accurately and used the battery to move the new one to match.
ahh I thought you do this on the old one :D Like a pacemaker for the clicking going away :D

Did you buy a brand new actuartor ?

how can i see if it matches with the new one ?? didnt unterstand, maybe you have some photos ;)

Best Regards

JBRollo
Posts: 39
Joined: 6 October 2005
Year and Model: 2012 Volvo S60 T5
Location: Tallahassee, FL, USA

Post by JBRollo »

I bought a new one I think. But I would not be against trying a used one. Sorry, no photos available. I sold the car.
Don't do anything to the old one. Its most probably in the correct position if its clicking.
Its a bit like setting a clock. Make both point the same way using the old one as the standard..
You will know its correct when you put in in as it will line up perfectly. If it doesn't, you will likely have to take it to the dealer to have them calibrate it $$$.

CoupeC70
Posts: 29
Joined: 14 March 2019
Year and Model: C70 Coupe '01
Location: Hessen
Has thanked: 5 times

Post by CoupeC70 »

Ok, because its a quadrangular head, how did you saw it ?

outside it can be the same position , but inside it can be wrong ?7


for example the old one has full left position and the new one full right... but the quadragular head looks like same position

JBRollo
Posts: 39
Joined: 6 October 2005
Year and Model: 2012 Volvo S60 T5
Location: Tallahassee, FL, USA

Post by JBRollo »

I would make the new one full left. That would make it match the hole the shaft has to go into it when you install it. If unsure, You might put one screw in it and test and try to test it.
Keep in mind I'm doing this from memory but I have done two Volvos using this method and they both worked well.

jimmy57
Posts: 6694
Joined: 12 November 2010
Year and Model: 2004 V70R GT, et al
Location: Ponder Texas
Has thanked: 4 times
Been thanked: 320 times

Post by jimmy57 »

The to pins shown go to motor, one pin through diodes.
The other three go to potentioneter. Use the two next two, each beside the motor pins, and measure with ohmmeter. If you measure the resistance of the old and run the new to get it close to that value measured on the me pins on new one then you will be OK.
NOTE! if the calibration was run with that motor not connected to door either through being disconnected or due to broken external drive gear or lever, then the new part will not fix it. The calibration will have put wide range value in memory and with it fixed it will IMMEDIATELY try to move that motor to the wrong stored end point and store a code and stop functioning repeatedly.

CoupeC70
Posts: 29
Joined: 14 March 2019
Year and Model: C70 Coupe '01
Location: Hessen
Has thanked: 5 times

Post by CoupeC70 »

hmmm

it seems very difficult

JBRollo
Posts: 39
Joined: 6 October 2005
Year and Model: 2012 Volvo S60 T5
Location: Tallahassee, FL, USA

Post by JBRollo »

I never used the procedure jimmy57 describes above.

CoupeC70
Posts: 29
Joined: 14 March 2019
Year and Model: C70 Coupe '01
Location: Hessen
Has thanked: 5 times

Post by CoupeC70 »

Maybe I can try first a clean inside the actuator

User avatar
RickHaleParker
Posts: 7129
Joined: 25 May 2015
Year and Model: See Signature below.
Location: Kansas
Has thanked: 8 times
Been thanked: 958 times

Post by RickHaleParker »

If I'm interperting jimmy57 & JBRollo correctly.

1. Measure the old one to determine the Electrical End Point.
2. Move the motor on the new one until you reach the same Electrical End Point on the new one.
3. Adjust the Mechanical End Point on the new one to match the Electrical End Point determined in step one and set in step two.
⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙⸙
1998 C70, B5234T3, 16T, AW50-42, Bosch Motronic 4.4, Special Edition package.
2003 S40, B4204T3, 14T twin scroll AW55-50/51SN, Siemens EMS 2000.
2004 S60R, B8444S TF80 AWD. Yamaha V8 conversion
2005 XC90 T6 Executive, B6294T, 4T65 AWD, Bosch Motronic 7.0.

Post Reply
  • Similar Topics
    Replies
    Views
    Last post